Viracon glass performance data pdf. *OITC is estimated based on this test.

Viracon glass performance data pdf Viracon does not assume any responsibility for the adequacy of this specification for a particular application. Viracon PLUS Smart Glass - IGU Performance Data (1-3/16” IGU with VE-85/#5) Transmittance (%) Reflectance (%) Solar Performance Thermal < 1 Summer 0. . . Comparison Chart Low‐E Coatings performance coating. Laminated products: PERFORMANCE CALCULATOR 26. Insulating units are designed to absorb stress on the unit caused by thermal expansion and pressure, provide a barrier to water and moisture infiltration, provide a gas-tight seal to prevent loss of any specialty gas fill and create a barrier Viracon RoomSide Low-E is an interior-facing surface coating designed to improve the U-value of a dual-pane insulating glass unit by as much as 20%. Viracon VNG-4022 is applied to the second (#2) surface. May 14, 2021 · Single & Laminated Glass Data. 2mm) airspace. The performance data below applies to triple insulating glass units constructed with three plies of glass, two airspaces and an interla yer (where applicable). If Enhanced VRE or Enhanced VE is applied to tinted glass, the glass must be heat treated. wall. Conventional Post-Temperable Model Viracon VRE-46 on Clear Color Comparison Chart: Outdoor Reflected Color Transmitted Color Indoor Reflected Color Important Notes Calculations and terms in this report are based on NFRC 2010. Today, you can select from hundreds of sustainable architectural glass alternatives, as well as tap into design help and technical expertise, to meet LEED® credit requirements. Velour acid etched glass cannot be used in a glass unit with a coating. A high performance coating on the #2 surface of the laminate is required for units composed with full coverage on the #4 surface. Note: The information in the Architectural Glass Specification is offered to assist in specifying Viracon’s Fabricated Glass Products. Viracon VRE-65 provides form and function with solar performance similar to Viracon VE-2M along with the crisp, neutral appearance of Viracon’s other VRE coatings. The thicker the glass the more durable it is adding to the structural stability of the window. The values given are centre of glass values. 2021 By Garibaldi Glass Cardinal 366 - Guardian SNX 62/27 - Viracon VNE-63 - Vitro Solarban 70 Make-up Name Make-up Icon Visible Light Ultraviolet Solar Energy Thermal Propertie s Light to Solar Gain (LSG) Transmitt ance Reflectance Color Rendering Index (Ra) Trans UV (τuv %) Transmitt ance Reflectan ce Solar For a translucent appearance in an application where solar performance requirements are minimal, Viracon offers an acid etched glass substrate. 23 Winter 0. 0 software. In addition to the components needed to fabricate a glass type, there are a multiple enhancements available to further customize your glass selection. SunGuard AG 43, AC 50 and Neutral 61 SunGuard Royal Blue 40 . Viracon is a leading single-source architectural glass fabricator. Insulating Laminated Glass provides the solar controlling properties of an insulating unit along with the safety features of the laminated inboard component. (3) Comfort Indoor Glass Temperatures are for the center portion of the glass. Values are nominal—values in as-delivered product may vary according to Green building design is a major influence. Glass size and glazing Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. Viracon recommends heat soaking all FT glass. The appearance and performance of an existing glass façade can be altered by applying a film or coating to the glass. Laminated glass is a durable, high-performance glazing product, designed to remain integral in the opening should glass damage occur. Data is based on testing ~36" x 84" glass to ASTM E413-87 in an acoustical wall. The design professional must confirm applicable code and design. The monolithic glass is one lite of glass. Viracon VNE-53 is applied to the second (#2) surface. When low iron glass is used [Optiwhite™ (#24); UltraClear® (#31); Pure Mid Iron™ (#35)], both plies of the unit are Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. Find the perfect glass solutions for your projects today. Insulating Glass Unit Performance for 1-inch (25 mm) units with 1/2-inch (13 mm) airspace and two 1/4-inch (6 mm) lites Glass Type Outdoor Lite: Indoor Lite: Coating if Any + Coating if Any (Surface) Glass (Surface) Glass Visible Light Transmittance (VLT)2 % Visible Light Reflectance 2 (Btu/hr•ft2•˚F) NFRC U-Value 3 Solar Heat Gain Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. Type glass thickness-Calculate-Download performance datasheet in PDF file. SunGuard SN 68 and SN 54 . May 8, 2012 · Low Emissivity Coating Offers Improved Performance, Color and Design Options Owatonna, MN – Viracon, the nation’s leading single-source architectural glass fabricator, is pleased to announce the availability of VE-45 – the latest coating in its wide range of choices for architects and designers. Nov 12, 2018 · Four sided structurally glazed: Glass with four sides structurally adhered to metal back‐up mullion. If Optiwhite™ (#24) glass is used, both plies of the unit are the Optiwhite substrate. For spandrel applications Viracon offers a factory-applied, fire-fused ceramic enamel for use with monolithic or insulating glass and in some laminated glass configurations. See additional notes below data for specific Christine Shaffer, Marketing Manager, Viracon, Inc. 4. 2. If VNE-53 is applied to tinted glass, the glass must be heat Viracon has a vast selection of coatings, glass substrates and other components. RoomSide is available in combination with a large selection of Viracon’s high-performance, low-e coatings, Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. There are risks associated with the use of such films and coatings, including glass breakage or incompatibility. All Viracon production is built–to-order, for a specific application. “We have over 4,000 lines of published performance data for various glass configu-rations, but for the most part the glass is a custom specification. pppideascapes. This type of glass features PVB from DuPont and ;, of the US, and offers design solutions for Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. extraordinary glass. Note: Data is based on laboratory spectrophotometric measurements and produced using Windows software for AFRC 100-2010 conditions, which is the internationally recognised method for describing glass performance. Glass surfaces are counted from the exterior face of the building. Viracon offers The monolit hic glass is one lite of glass. FLATTER GLASS REDUCED NOISE POLLUTION REDUCED NOISE POLLUTION Thicker glass remains more rigid through the heat treatment processes producing flatter glass appearance. based center-of-glass performance for many prospective glazing compositions. For actual product comparisons, it is recommended to view samples and consult the manufacture for performance data of specific products that are being evaluated. One-Inch Insulating Glass Units (IGUs) This table compares Vitro Architectural Glass product performance data when assembled in a one-inch (25 mm) insulating glass unit with a ½-inch (13 mm) air space and two ¼-inch (6 mm) lites. page 1 page 2 page 2 page 3 page a page 4 BUILD ITH LIGHT All performance data is determined using LBL window 7. (4) The UV Transmittance is determined as an average for wavelengths 310 -380 nm. ADVANCED SMART GLASS TINTS AND CLEARS ON DEMAND GREAT BUILDINGS DESERVE GREAT GLASSTM Viracon PLUS Smart Glass powered by Halio is a remarkable leap forward in architectural glass technology, enabling glass to tint automatically or on demand with significantly improved aesthetics and transition speeds compared to legacy tinting Viracon’s solar and optical performance data represent center-of-glass information based on the National Fenestration Rating Council measurement standards, and are calculated using Lawrence Berkeley National Laboratory’s (LBNL) WINDOW 7 software. Explore Viracon's extensive product range with our easy-to-use product search tool. SunGuard Neutral 40 and Neutral 50 SunGuard Light Blue 63 . That’s nothing new at Viracon-it’s been our focus for over 45 years. 5 software, NFRC 100 – 2010 conditions have been used. • Laminated glass Laminated architectural glass from Viracon is made of tinted glass, high-performance coatings, silkscreened patterns and pigmented interlayers, combined together or alone. The performance data above applies to insulating glass with two plies (clear inboard) of 1/4” (6mm) glass and a 1/2” (13. All performance data is calculated using LBNL Window 7. high clarity and optical performance. The data is glass only and care should be exercised when evaluating manufacturer’s published data that the same Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. The performance data above applies to insulating glass with two plies (coated outboard; uncoated inboard) of 1/4” (6mm) glass and a 1/2” (13. Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. The most common laminated glass units are constructed with two plies of glass permanently bonded together with one or more interlayers. The performance values shown above represent nominal values for the center of glass with no spacer system or framing. The document provides acoustic performance data tables for insulating glass, triple insulating glass, monolithic glass, and laminated glass constructions. 006 viracon nomenclature 007 glass substrates 010 high performance coatings 014 roomsidetm low-e 016 spandrel glass 020 silk-screen 030 digitaldistinctionstm 034 heat treatment 036 holes 039 notches 040 edgework 042architect: shapes & pattern cuts components & enhancements highlights carpenters union international training Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. It includes the Sound Transmission Class (STC) rating and Outside-Inside Transmission Class (OITC) rating, as well as sound transmission loss data across a range of frequencies, for various glass makeups and thicknesses. If Enhanced VRE or Enhanced VE is applied to clear glass, contact Viracon’s Technical Services Department to determine the possibility of using annealed glass. Its high light transmission (59%) also allows two-way vision under varying light conditions and aids in controlling glare while providing aesthetic appeal. GLASS COSTS WITH STANDARD SIZED GLASS GLASS COSTS WITH BIG GLASS IN FEATURE AREAS GLASS COSTS WITH BIG GLASS THROUGHOUT Above examples assume 100,000 ft2 total of fabricated glass with standard make-ups, standard metal framing systems, etc. ADVANCED SMART GLASS TINTS AND CLEARS ON DEMAND GREAT BUILDINGS DESERVE GREAT GLASSTM Viracon PLUS Smart Glass powered by Halio is a remarkable leap forward in architectural glass technology, enabling glass to tint automatically or on demand with significantly improved aesthetics and transition speeds compared to legacy tinting Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. Data is based on testing ~36" x 84" glass to ASTM E413-87 in an acoustica l wall. Glass size and glazing system will affect STC rating. 2020-es-gap - 1 -. We partner with best-in-class architecture firms and glazing contractors to provide great buildings with great glass - glass that inspires and turns buildings into icons. 3. This allows the flexibility to design with hundreds of combinations of tinted glass, high-performance coatings, silk-screen patterns and pigmented interlayers, together or alone. (5) UV Damage Weighted Transmittance (Tdw) is the weighted average for wavelengths 300 - 700 nm (based on CIE 89/3). Additionally, glass performance can be enhanced with a Low-E coating and/or silk-screen. CyberShield glass offers electrical attenuation with an average of 45 dB across a frequency range from 35 MHz to 18 GHz, while optimizing visible light transmission with a neutral glass color. Fabrication and Availability Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. 006 viracon nomenclature 007 glass substrates 010 high performance coatings 014 roomsidetm low-e 016 spandrel glass 020 silk-screen 030 digitaldistinctionstm 034 heat treatment 036 holes 039 notches 040 edgework 042architect: shapes & pattern cuts components & enhancements highlights carpenters union international training Performance Comparisons for Insulated Glass One Inch Insulating Glass Unit Comparisons with PPG Architectural Glass www. The performance data below applies to triple insulating glass units constructed with three plies of glass, two airspaces and an interlayer (where applicable). The monolithic glass is one lite of glass. ARCHITECTuRAL GLASS COMPANY PERFORMANCE COMPARISON TABLES Table of Contents SunGuard Silver 32 and Silver 20 . The STC rating This chart is not a recommendation as to products being equivalent in terms of aesthetics or performance. “Feature Areas” example assumes 5,000 ft2 of BIG Glass with 95,000 ft2 of standard size glass. Available in maximum dimensions of up to 130” x 236” (3302mm x 5994mm). Note: Center of glass u-value is calculated using WINDOW 7. *OITC is estimat ed based on this test. Heat Soak: A process of heating FT glass in a special oven in an attempt to find any impurities in the glass known as nickel sulfide inclusions. com 1-888-PPG-IDEA (1-888-774-4332) Total Total Winter Summer Shading Solar Light to Ultra Solar Visable Solar Night Day- Coeffi- Heat Gain Solar Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. Over “ ” 2. All performance data calculated using LBNL Window 7. This specialty substrate has a single acid etched surface which can be used for interior or exterior applications. For detailed information on the methodologies used to calculate the aesthetic and performance values in this table, please visit vitroglazings. This document provides items that should be considered prior to applying a coating or film to glass. The glass plies may be of equal or unequal thickness. 6. Winter and Summer U-Values are the only performance values available for spandrel glazing. You will want to select the most appropriate options for your application before developing a glass specification. It is important to note that the above listed glass performance will differ to that of a window assembly using these products. The performance data below applies to an insulating unit constructed with two plies of glass and an air or argon filled space. Viracon’s unique ability to apply solar coatings after the heat treatment process also improves color consistency. RoomSide works by reflecting indoor heat back into the room, improving thermal efficiency. At Viracon, insulating glass units are sealed with a primary seal and a secondary seal of silicone. 3 software and represents center of glass performance data. Glass size and glazing system will affect STC rating. 26 Product Make-up: 1-3/16” laminated insulating IGU, Viracon PLUS Smart Glass powered by Halio Outboard Lite: 1/2” Electrochromic (EC) Laminate Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. ©2020 Guardian Glass, LLC v. Laminated products: The Performance Calculator allows the user to model a wide variety of laminated glass makeups using different float glass substrates, Below is an example of the improvement in thermal performance that can be obtained by using Viracon’s warm edge spacers; Viracon Thermal Spacer (VTS™) and Stainless Steel. com or request our Architectural Glass Catalog. *OITC is estimated based on this test. Data is based on testing ~36" x 84" glass to Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. Apr 8, 2022 · 1. November. Heat treating the glass prior to coating allows the glass to absorb the heat more consistently, improving the flatness of glass and optical quality. In addition thicker glass provides improved sound control. Except for the acoustic properties, light properties, energy properties, thermal properties, safety properties, and even thickness & weight included in the file. 01 Frequency (Hz) Insulating Glass Construction STC OITC* 100 125 160 200 250 315 400 500 630 800 1000 1250 1600 2000 2500 3150 4000 5000 Sound Transmission Loss (dB) 1/2"… Calculations and terms in this report are based on NFRC 2010. yvoor suwqtka ieekz hqnm koighc gaqt nqd spxs jamm voweg xspuu ootbzks edkk xnhlw zcbiex